KnownCarProblemsHome › Chevrolet › Aveo › 2007
2007 Chevrolet Aveo Problems and Recalls
Owners filed 216 complaints with NHTSA about the 2007 Chevrolet Aveo, most often about the air bags (39% of complaints, typically around 38,500 miles). It is the 2nd most complained-about Aveo model year since 2000 and has 2 recalls.
Most common 2007 Chevrolet Aveo problems
Air bags
84 complaints · 39%Half of these problems showed up before 38,500 miles. Parts named most often: frontal.
The contact owned a 2007 Chevrolet Aveo. While driving at an unknown speed, the contact's vehicle crashed head on into another vehicle. The air bags failed to deploy. The contact sustained neck injuries that did not require medical attention. A police report was filed. The vehicle was destroyed. The manufacturer was…
The contact owns a 2007 Chevrolet Aveo. The contact stated that the air bag warning light illuminated. The vehicle was taken to a dealer where it was confirmed the air bag was not working properly. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 31,840.…
Electrical
50 complaints · 23%Half of these problems showed up before 66,000 miles. Parts named most often: ignition, wiring, 12v/24v/48v battery.
Unable to move gear from park to drive over seven times mechanic informed failure in gear box also informed that this is a manufacturring defect.
About a week ago I started smelling something burning. Thought I was mistaken. Tried to crank the car today and the battery was dead. Had a relative jump it and found the daytime running lights stay on even when the car is off. In researching what the problem could be I found that a recall has been issued regarding…
Lights
32 complaints · 15%Half of these problems showed up before 86,000 miles. Parts named most often: headlights.
Since the drl module was replaced as a recall item, I have had to replace each headlight every 2-8 weeks due to burning out. There is obviously a problem with the so-called "repair."
The dashboard over the speedometer becomes very hot and the key is hot when removed. I feel this may be related to recall 14236 regarding running lights. I am concerned about the recall 06133 regarding fuel line/fuse block as well.
Engine
29 complaints · 13%Half of these problems showed up before 58,500 miles. Parts named most often: engine, cooling system, exhaust system.
While driving the throttle is sometimes stuck in a lower gear causing me to move at a limited speed while on the road. There has always been a problem with the throttle such as erratic acceleration, but only recently it has become stuck.
While driving on i95 my rpms dropped to zero without warning and I was able to get it off the road. The tow truck driver said the engine was blown. It had 63,504 miles on it and the required maintenance had been done less than 1600 miles earlier. No lights or warning. Luckily I was able to get it off the road safely.
Transmission
14 complaints · 7%Half of these problems showed up before 27,000 miles. Parts named most often: automatic transmission, axle hubs, clutch assembly.
The contact owns a 2007 Chevrolet Aveo. The contact stated that the gear shifter would not release from park and caused the brake light switch to fail. The vehicle was taken to the dealer to have a diagnostic performed. The vehicle was repaired. The manufacturer was made aware of the failure. The failure mileage was…
I bought this 2007 chevy Aveo brand new with only 9 miles on it. After I put about 33,000 miles the A/C went out... On a brand new car! Then the console with the shifters lights went out, blinkers would stop blinking and just stay green. I went to start my car at 10pm and it wouldn't start it acted like it was going…
Brakes
13 complaints · 6%Half of these problems showed up before 7,000 miles. Parts named most often: antilock/traction control/electronic limited slip, foundation components, pedals and linkages.
Tl contact owns a 2007 Chevrolet Aveo. While making a turn between 5-10 MPH, the contact heard a grinding noise coming from the front end of the vehicle. The dealer replaced the front wheel bearings and checked the air pressure, but the failure continued. The vehicle was taken to another dealer and they performed an…
Tl contact owns a 2007 Chevrolet Aveo. While parked in neutral, the emergency brake was applied and the vehicle moved approximately 30 feet. The contact stated that the driver side door also fell off of the vehicle. The road conditions were normal. The failure was not diagnosed by a dealer. The current and failure…
Suspension
11 complaints · 5%Half of these problems showed up before 19,500 miles. Parts named most often: front.
2007 Aveo 5 , new purchase in april 2008. 1. Highway driving is extremely scary, cannot drive at "posted speed limits in north america.roof howls & vibrates, we fear that roof will detach & blow off.tech: unable to reproduce. 2. Freezing outdoor temperatures, defroster fails, needs hand toweling, excessive moisture &…
Tl contact owns a 2007 Chevrolet Aveo. While making a turn between 5-10 MPH, the contact heard a grinding noise coming from the front end of the vehicle. The dealer replaced the front wheel bearings and checked the air pressure, but the failure continued. The vehicle was taken to another dealer and they performed an…
Speed control
10 complaints · 5%Half of these problems showed up before 38,500 miles. Parts named most often: cruise control.
Tl contact owns a 2007 Chevrolet Aveo. The contact stated that the check engine light illuminated and the vehicle suddenly accelerated. The vehicle was taken to the dealer who stated that the throttle body assembly needed to be replaced. She mentioned that she had to replace the throttle body assembly four times…
The contact owns a 2007 Chevrolet Aveo. The contact stated that the pedal position sensor switch failed, causing the vehicle to accelerate. The contact made an attempt to contact both the manufacturer and the dealer, but neither were responsive. The failure was not repaired. The failure mileage was 34,580 and the…
Complaints are owner reports to NHTSA, not verified defects. One complaint can name several components, so shares add up to more than 100%.
2007 Chevrolet Aveo recalls
Lights: headlights
Risk: If the drl module melts due to the heat generation, it could cause a vehicle fire.
Fix: Gm will notify owners, and dealers will install a revised drl module, inspect the wiring connector for heat damage, and clean the drl circuit grounds. Owners were sent interim notices on august 14, 2014. The recall began on february 6, 2015. Owners may contact general motors customer service at 1-800-222-1020 (chevrolet). General motors recall number for this campaign is 14236.
Full defect summary
General motors is recalling certain model year 2004-2008 chevrolet aveo vehicles equipped with daytime running lights (drl). In the affected vehicles, there may be heat generated within the drl module located in the center console in the instrument panel, which could melt the drl module.
Fuel system: fuel system, gasoline
Risk: If these conditions occurred in an actual crash, a vehicle fire could occur.
Fix: Dealers will replace the fuse block and install a new section of fuel line that has been redesigned free of charge. The recall began on november 16, 2006. Owners may contact chevrolet at 1-800-630-2438.
Full defect summary
On certain passenger vehicles equipped with a 1.6l engine, during a ncap severe frontal crash test, the fuel line in the engine compartment developed a fracture. In addition, the crash damage caused four short circuits in the fuse block, the combination of which allowed the fuel pump to continue running and fuel leaked onto the ground.
Recall repairs are free at any franchised dealer. Enter your VIN at nhtsa.gov/recalls to see which recalls are still open on your car.
Questions about the 2007 Chevrolet Aveo
- What are the most common problems with the 2007 Chevrolet Aveo?
- By NHTSA owner complaints: air bags (84 complaints, typically around 38,500 miles); electrical (50 complaints, typically around 66,000 miles); lights (32 complaints, typically around 86,000 miles).
- How many recalls does the 2007 Chevrolet Aveo have?
- 2 recalls listed by NHTSA, the latest from May 19, 2014 (lights). Check your VIN at nhtsa.gov/recalls to see which ones are still open on your car.
- Is the 2007 a bad year for the Chevrolet Aveo?
- It is the 2nd most complained-about Aveo model year since 2000, with 216 complaints. Complaint counts are not adjusted for how many cars were sold, so popular years collect more of them, and the newest years have had less time to.