KnownCarProblems2001 Ford F-550 SD Problems and Recalls
Owners filed 29 complaints with NHTSA about the 2001 Ford F-550 SD, most often about the fuel system (45% of complaints, typically around 140,000 miles). It is 6th of 26 F-550 SD model years by number of complaints and has 6 recalls.
Most common 2001 Ford F-550 SD problems
Fuel system
13 complaints · 45%Half of these problems showed up before 140,000 miles.
The contact owns a Ford f550. While driving approximately 70 MPH the vehicle stalled without warning and was towed to an independent mechanic. The mechanic advised that the fuel tank would need to replace but the vehicle was not repaired. The contact stated that the part was not available because there was a high…
I have been experiencing power failure, fuel starvation on my 2001 f550 diesel truck. I replaced the filters today at the onset of the incident, but just replaced them about a month ago with my mechanic. It runs fine on level ground, but at an incline it loses power and barely makes it up a hill. I removed the tank…
Wheels and tires
8 complaints · 28%Parts named most often: valve.
Transmission
4 complaints · 14%Parts named most often: automatic transmission.
I have been experiencing power failure, fuel starvation on my 2001 f550 diesel truck. I replaced the filters today at the onset of the incident, but just replaced them about a month ago with my mechanic. It runs fine on level ground, but at an incline it loses power and barely makes it up a hill. I removed the tank…
Complaints are owner reports to NHTSA, not verified defects. One complaint can name several components, so shares add up to more than 100%.
2001 Ford F-550 SD recalls
Speed control: vehicle speed control
Risk: A vehicle fire could occur with or without the engine running.
Fix: Ford will notify owners that dealers will install a fused wiring harness in line with the scds. On 1999-2003 windstar vehicles with a leaking scds, dealers will also inspect the ABS control module connector and repair as necessary. Repairs will be completed free of charge. The safety recall began on october 27, 2009. Owners may contact ford at 1-888-222-2751.
Full defect summary
Ford is recalling model years 1995-2003 windstar, 2000-2003 excursion diesel, 1993-1997 and 1999-2003 f-250 sd through f-550 sd diesel, 1992-2003 e-150 through e-550, 1995-2002 explorer, 1997 and 2002 mercury mountaineer, 1995-1997 and 2001-2003 ranger, and 1994 f53 vehicles equipped with the texas instruments speed control deactivation switch (scds). The scds may leak internally and then overheat, smoke, or burn.
Engine: diesel
Risk: In the event of an engine stall, a crash could result without warning.
Fix: Dealers will inspect the sensor and replace it with an improved camshaft position sensor free of charge. The recall began on december 29, 2007. Owners may contact ford at 1-866-436-7332.
Full defect summary
On certain heavy duty trucks equipped with 7.3l diesel engines, the camshaft position sensor located on the engine of the vehicle may function intermittently, possibly resulting in an engine stall.
Speed control: vehicle speed control
Risk: Overheating could result in smoke or burn and an underhood fire.
Fix: Dealers will install a fused wiring harness into the speed control system free of charge. The recall began on august 7, 2006. Owners may contact ford at 1-866-436-7332. (note: also see recalls 05v017 and 05v388)
Full defect summary
On certain trucks equipped with speed control, gasoline or natural gas engines, the speed control deactivation switch may overheat.
Visibility and wipers: motor
Risk: Loss of visibility while driving increases the risk of a crash.
Fix: Dealers will inspect the date code on the wiper motor. Motors built with the suspect time frame will have the wiper motor gear case cover replaced. Owner notification began august 20, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-866-436-7332.
Full defect summary
Vehicle description: passenger cars, sport utility vehicles, and light and medium duty pickup trucks. A switch located in the plastic cover of the wiper motor gear case could malfunction and overheat, potentially resulting in loss of intermittent wiper function, loss of wiper park function, complete loss of wiper function, or ignition of the plastic cover material. Switch malfunction is most likely to occur when the intermittent setting of the wipers is being used, or when snow or ice obstructs the blades from returning to the "parked" position at the bottom of the windshield. These vehicles were built at the following assembly plants: atlanta plant from 2/11/00 through 7/31/00; chicago plant from 2/14/00 through 8/4/00; kansas city plant from 2/26/00 to 9/4/00; kentucky truck plant from 2/18/00 to 8/31/00; michigan truck plant from 2/23/00 through 8/3/00; norfolk plant from 2/21/00 thro
Seat belts: buckle assembly
Risk: In the event of a crash, the restraint system may not provide adequate occupant protection, increasing the risk of personal injury to the seat occupant.
Fix: Dealers will inspect the front outboard seat belt buckles and if the buckle fails the inspection process, it will be replaced. Owner notification began july 25, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-866-436-7332.
Full defect summary
Vehicle description: passenger and sport utility vehicles, pickup trucks, and minivans. Equipped with seat belts supplied by trw. It is possible that the driver's and/or front passenger's outboard seat belt buckle may not fully latch. Ford crown victoria built at st. Thomas assembly plant from 4/17/00 - 5/29/01 mercury grand marquis built at st. Thomas assembly plant from 4/17/00 - 5/29/01. Lincoln town cars built at wixom assembly plant from 3/27/00 - 5/30/01. Lincoln navigators built at michigan truck plant from 4/11/00 - 5/31/01. Ford windstars built at oakville assembly plant from 3/23/00 - 5/30/01. Ford rangers built at twin cities plant from 3/28/00 - 5/30/01, and also at the edison plant from 3/13/00 - 5/25/01. Ford f-150 truck built at norfolk plant from 4/18/00 - 5/25/00; at ontario plant from 5/10/00 - 5/28/01; at kansas city plant from 9/11/99 - 5/25/01; and at cuautitlan plan
Wheels and tires: valve
Risk: If not maintained, could result in a sidewall zipper failure. A zipper failure during inflation of a damaged tire could result in injury to someone near the tire.
Fix: Dealers will inspect the valve stems for leakage, and will replace both the valve stem and the tire if leakage is present. Owner notification began march 28, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact ford at 1-800-392-3673.
Full defect summary
Vehicle description: trucks equipped with commercial truck tires that have steel cords in the tire sidewall. The valve stems may have been torn or damaged during assembly and could leak causing sidewall damage.
Recall repairs are free at any franchised dealer. Enter your VIN at nhtsa.gov/recalls to see which recalls are still open on your car.
NHTSA defect investigations
Engine stalling
Summary
In a december 3, 2007 letter, ford advised NHTSA that it will conduct a safety recall to replace the cam position sensor (cps) in approximately 1.2 million subject vehicles to address reports of engine stalling.a new design cps with improved performance and durability will be installed as a remedy.owner notifications will begin in december 2007. The subject vehicles are durable, full-sized, medium duty trucks commonly used for commercial purposes, rescue/emergency response, and commercial or recreational towing.cps failure is comparable to unexpectedly turning the key off since the signal it produces is vital to the electronic engine control system.cps signal loss terminates fuel injection r
Engine compartment fires
Summary
Ea05-005 is closed with ford?s actions in recalls 05v-017, 05v-388, and 06v-286, recalling approximately 6.7 million vehicles equipped with texas instruments speed control deactivation switches (scds).the brake systems in these recalled vehicles generate a vacuum that can potentially cause the scds to fail and, in certain switch installation orientations, catch fire.ford is also including the entire population of 1998 explorers.ford has informed odi that testing to determine the cause of failures in the 1998 explorers will continue after this investigation is closed.odi believes that the vehicles exhibiting the factors causing scds failure described in this report correlate well with the obs
Front seat belt buckle assembly
Summary
During the initial recall campaign in 2001, the subject vehicles were inspected by ford dealerships using a test tool that would detect a defective front seat outboard seat belt buckle assembly.approximately one million vehicles passed the inspection test for one or both front buckles.subsequent to the recall service action, odi received 15 consumer reports alleging that a passed inspection buckle subsequently failed to latch or inadvertently unlatched during use.in addition, ford has identified 543 owner and field reports alleging buckle failure subsequent to passing the inspection test.ford tested and examined over 100 warranty-returned buckles and found that 44% of the buckles had no prob
Front seat belt buckle assembly
Summary
Under recall campaign (01v227), ford recalled approximately 1.3 million vehicles to inspect and if necessary replace the front driver and/or passenger seat belt buckle.approximately 1.1 million owners responded by taking their vehicles to a dealer for inspection of the buckle using a specialized buckle test tool.ford reported that 829,927 vehicles had both buckles pass the tool test and another 167,336 vehicles had one buckle pass.odi and ford received complaints alleging seat belt buckle failure shortly after passing the original recall inspection service.complainants alleged that the buckle failed by either not latching or false-latching (partial engagement of the latch to the latch plate)
Accelerator pedal sensor (etc)
Summary
Failure counts from odi?s analysis are stated above; see the additional problem experience discussion in the summary report.ford data contained duplicative reports for 4 odi complaints and 1 crash.three crashes were allegedly due to intermittent operation of the electronic throttle control (etc) pedal, one crash occurred when an etc disabled vehicle was struck by another motorist, one report contained no detail.the injuries were minor.an issue involving fixed etc pedals was investigated also, however failure reports and populations are not shown above; see summary report for detail.although ford has used etc based throttle control systems for many years, the pap feature was new for my 2002.t
Rapid tire deflation
Summary
This investigation was opened on certain ford pickup trucks and vans to evaluate the effects of a valve stem ejection (with rapid air loss) and a slow leaking valve stem on vehicle handing.during the investigation, odi evaluated over 1,100 complaints and warranty claims, conducted vehicle dynamic testing on a subject vehicle with the failure mode replicated, interviewed owners, and examined complaint vehicles in the field.the results of the test program indicates the effect of a valve stem ejection on these vehicles is easily controlled. Further, with a population of almost 900,000 vehicles, having two to four years of exposure, odi is aware of only 3 minor crashes and is unaware of any inju
Sector shaft fractures
Summary
This ea was opened based on a response received from ford motor company to an information request (ir) submitted during sq00-018.ford stated in an internal service message that it had changed the steering gear sector shafts and pitman arms installed 1999 model year f-series super duty vehicles on march 22, 1999.ford stated that these design changes were implemented to make improvements in vehicle steering and handling, and that virtually all of the reported fractured sector shafts were the result of extraordinary, possibly multiple, impacts.an engineering analysis closing report is attached.
Questions about the 2001 Ford F-550 SD
- What are the most common problems with the 2001 Ford F-550 SD?
- By NHTSA owner complaints: fuel system (13 complaints, typically around 140,000 miles); wheels and tires (8 complaints); transmission (4 complaints).
- How many recalls does the 2001 Ford F-550 SD have?
- 6 recalls listed by NHTSA, the latest from October 13, 2009 (speed control). Check your VIN at nhtsa.gov/recalls to see which ones are still open on your car.
- Is the 2001 a bad year for the Ford F-550 SD?
- It is 6th of 26 F-550 SD model years by number of complaints, with 29 complaints. Complaint counts are not adjusted for how many cars were sold, so popular years collect more of them, and the newest years have had less time to.