KnownCarProblems2003 Subaru Baja Problems and Recalls
Owners filed 38 complaints with NHTSA about the 2003 Subaru Baja, most often about the brakes (21% of complaints, typically around 8,000 miles). It is the most complained-about Baja model year since 2000 and has 10 recalls.
Most common 2003 Subaru Baja problems
Brakes
8 complaints · 21%Half of these problems showed up before 8,000 miles. Parts named most often: antilock/traction control/electronic limited slip, antilock.
This vehicle's brakes are defective. The ABS is too easily activated by bumps or debris on the road during routine stops under normal environmental conditions, resulting in loss of decelaration of varying degrees of severity. This has caused one accident already and almost caused another one on 12mar04. We have…
My Subaru Baja has an intermittent braking problem. When travelling at about 10 - 20 miles per hour it will not stop but just slow down even though pressing the brake as hard as I can. The brakes do not go all the way to the floor. Two days ago I almost hit a car when doing about 10 miles per hour and the brakes…
Transmission
7 complaints · 18%Half of these problems showed up before 12,000 miles. Parts named most often: automatic transmission, driveline, clutch assembly, manual transmission.
The contact owns a 2003 Subaru Baja. The contact stated after changing a flat tire with the spare tire the rear end of the vehicle started smoking. The smoke was cause by the spare tire due to the different tread and size caused the differential to malfunction. The contact drove the vehicle to a local mechanic and the…
Hesitation, no power on acceleration. Computer has been reprogrammed by Subaru in nj.. Trans engaging hard from a dead stop on acceleration.
Engine
6 complaints · 16%Parts named most often: engine, exhaust system.
When trying to accelerate from a complete stop, the vehicle hesitated. The dealer reprogrammed the computer/replaced the oxygen sensor and replaced the ecu, but the problem still continued. The consumer stated the timing belt was also replaced, however the vehicle stalled twice.
Vehicle pulls to left when driving. Vehicle shudders when driving in snow, hesitation when taking off in first gear, reverse lights stop working.
Air bags
5 complaints · 13%Electrical
3 complaints · 8%Hesitation, no power on acceleration. Computer has been reprogrammed by Subaru in nj.. Trans engaging hard from a dead stop on acceleration.
When trying to accelerate from a complete stop, the vehicle hesitated. The dealer reprogrammed the computer/replaced the oxygen sensor and replaced the ecu, but the problem still continued. The consumer stated the timing belt was also replaced, however the vehicle stalled twice.
Steering
3 complaints · 8%Steering became very difficult, with loud banging/popping noises while turning steering wheel...worsened as vehicle warmed up...would feel as though steering wheel was being jerked out of my hands. Vehicle was repaired by replacing viscous clutch in center differential (at transmission)...was told that many similar…
The contact owns a 2003 Subaru Baja. The contact stated that while making a turn, the steering wheel became difficult to maneuver without warning. The contact mentioned that the failure occurred after the vehicle was serviced under NHTSA campaign number: 14v399000 (air bags). The vehicle was not diagnosed or repaired.…
Suspension
3 complaints · 8%The contact owns a 2003 Subaru Baja. The contact stated that while turning at 2 MPH, a noise was heard coming from the rear passenger side. The vehicle was maneuvered to the shoulder and the contact smelled a burning odor. Upon examining the vehicle, the contact also noticed that the rear passenger tire was rubbing…
Complaints are owner reports to NHTSA, not verified defects. One complaint can name several components, so shares add up to more than 100%.
2003 Subaru Baja recalls
Air bags: inflator module
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Fix: Subaru will notify their owners. General motors will notify saab owners. Dealers will replace the passenger air bag inflators, free of charge. The recall began january 7, 2020. Subaru owners may contact subaru customer service at 1-844-373-6614. Saab owners may contact the saab customer assistance center at 1-800-955-9007. Subaru's number for this recall is tkb-20.
Full defect summary
Subaru of america, inc. (subaru) is recalling certain 2009-2013 forester, 2003-2006 baja, 2004-2011 impreza, 2004-2014 wrx (including sti), 2003-2014 legacy and outback, and 2006 saab 9-2x vehicles originally sold, or ever registered, in the states of arizona, arkansas, delaware, district of columbia, illinois, indiana, kansas, kentucky, maryland, missouri, nebraska, nevada, new jersey, new mexico, north carolina, ohio, oklahoma, pennsylvania, tennessee, virginia, and west virginia or "zone b." these vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Air bags: inflator module
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Fix: Subaru will notify their owners. General motors will notify saab owners. Dealers will replace the passenger air bag inflators with alternate inflators, free of charge. The recall began january 7, 2020. Subaru owners may contact subaru customer service at 1-844-373-6614. Saab owners may contact the saab customer assistance center at 1-800-955-9007. Subaru's number for this recall is tka-20.
Full defect summary
Subaru of america, inc. (subaru) is recalling certain 2009-2013 forester, 2003-2006 baja, 2004-2011 impreza, 2004-2014 wrx (sti included), 2003-2014 legacy and outback, and 2005-2006 saab 9-2x vehicles originally sold, or ever registered, in the states of alabama, california, florida, georgia, hawaii, louisiana, mississippi, south carolina, texas, puerto rico, american samoa, guam, the northern mariana islands (saipan), and the u.s. Virgin islands or "zone a." these vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Air bags: inflator module
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Fix: Subaru will notify their owners. General motors will notify saab owners. Dealers will replace the passenger air bag inflators, free of charge. The recall began january 7, 2020. Subaru owners may contact subaru customer service at 1-844-373-6614. Saab owners may contact the saab customer assistance center at 1-800-955-9007. Subaru's number for this recall is tkc-20.
Full defect summary
Subaru of america, inc. (subaru) is recalling certain 2009-2013 forester, 2003-2006 baja, 2004-2011 impreza, 2004-2014 wrx (including sti), 2003-2014 legacy and outback, and 2005-2006 saab 9-2x vehicles originally sold, or ever registered, in the states of alaska, colorado, connecticut, idaho, iowa, maine, massachusetts, michigan, minnesota, montana, new hampshire, new york, north dakota, oregon, rhode island, south dakota, utah, vermont, washington, wisconsin, and wyoming or "zone c." these vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Air bags: inflator module
Risk: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Fix: Subaru will notify their owners. General motors will notify saab owners. Dealers will replace the passenger frontal air bag inflator, free of charge. The recall began august 26, 2016. Owners may contact subaru customer service at 1-856-488-8500. Saab owners may contact gm at 1-800-955-9007. Subaru's number for this recall is tka-16.
Full defect summary
Subaru of america, inc. (subaru) is recalling certain model year 2003-2004 legacy, outback, 2009-2011 legacy, outback, forester, 2006-2011 impreza, tribeca, 2003-2006 baja, and 2006 saab 9-2x vehicles originally sold or that have ever been registered in alabama, california, florida, georgia, hawaii, louisiana, mississippi, south carolina, texas, puerto rico, american samoa, guam, the northern mariana islands (saipan), and the u.s. Virgin islands, or "zone a." these vehicles may be equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Air bags: inflator module
Risk: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Fix: Subaru will notify their owners. General motors will notify saab owners. Dealers will replace the passenger frontal air bag inflator, free of charge. The recall began august 24, 2016. Owners may contact subaru customer service at 1-856-488-8500. Subaru's number for this recall is tkb-16. Note: this notice is only for vehicles that were not covered by 16v-358 for zone a.
Full defect summary
Subaru of america, inc. (subaru) is recalling certain model year 2003-2004 legacy, outback, 2006-2008 impreza, tribeca, 2006 saab 9-2x, and 2003-2006 baja vehicles originally sold or that have ever been registered in arizona, arkansas, delaware, district of columbia, illinois, indiana, kansas, kentucky, maryland, missouri, nebraska, nevada, new jersey, new mexico, north carolina, ohio, oklahoma, pennsylvania, tennessee, virginia, and west virginia, or "zone b." these vehicles may be equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Air bags: inflator module
Risk: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Fix: Subaru will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began august 24, 2016. Owners may contact subaru customer service at 1-856-488-8500. Subaru's number for this recall is tkc-16. Note: this recall covers vehicles that were not previously covered in 16v-358 for zone a or 16v-359 for zone b.
Full defect summary
Subaru of america, inc. (subaru) is recalling certain model year 2003-2004 legacy, outback, and baja vehicles originally sold or that have ever been registered in alaska, colorado, connecticut, idaho, iowa, maine, massachusetts, michigan, minnesota, montana, new hampshire, new york, north dakota, oregon, rhode island, south dakota, utah, vermont, washington, wisconsin, and wyoming, or "zone c.". These vehicles may be equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Air bags: inflator module
Risk: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Fix: Subaru will notify their owners and general motors will notify saab owners. Dealers will replace the passenger air bag inflator, free of charge. The subaru recall began on june 17, 2015. Owners may contact subaru customer service at 1-800-782-2783. The saab recall began on july 27, 2015. Owners of saab vehicles may call 1-800-955-9007. Subaru's number for this recall is wqr-53. Note: the recall completely supersedes recall 14v-399 (wql-48) and partially supersedes recall 14v-763 (wqp-51) in that model year 2004 through 2005 subaru impreza and model year 2005 saab 9-2x vehicles are now only par
Full defect summary
Subaru of america, inc. (subaru) is recalling certain model year 2003-2004 subaru baja vehicles manufactured january 22, 2003, to july 21, 2004, 2004-2005 impreza vehicles manufactured january 28, 2003, to may 31, 2005, 2003-2008 subaru legacy vehicles manufactured january 22, 2003, to may 2, 2008, 2003-2008 subaru outback vehicles manufactured february 18, 2003, to may 5, 2008, and 2005 saab 9-2x vehicles manufactured february 11, 2004, to march 17, 2005. The affected vehicles are equipped with a passenger side frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture upon its deployment.
Air bags
Risk: In the event of a crash necessitating deployment of the passengerâs frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Fix: Subaru will notify their owners. Dealers will replace the passenger air bag inflator, free of charge. The recall began on january 15, 2015. Owners may contact subaru at 1-800-782-2783. Subaru's number for this recall is wqp-51. Note: this recall supersedes recall 14v-471. This recall has been partially superseded by 15v-323. All 2005 model year subaru legacy and outback vehicles will now be repaired under recall 15v-323.
Full defect summary
Subaru of america, inc. (subaru) is recalling certain model year 2003-2004 legacy and outback vehicles, and 2003-2005 baja vehicles sold, or ever registered, in geographic locations associated with high absolute humidity. Specifically, vehicles sold, or ever registered, in puerto rico, hawaii, the u.s. Virgin islands, guam, saipan, american samoa, florida and adjacent counties in southern georgia, as well as the coastal areas of alabama, louisiana, mississippi and texas. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to rupture.
Transmission: automatic transmission
Risk: The vehicle could then move/roll without prior warning, increasing the risk of a crash.
Fix: Dealers will replace the automatic transmission parking rod assembly. Owner notification january 8, 2003. An interim owner notification will be sent during november 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact subaru at 1-800-782-2783.
Full defect summary
Certain sport utility and passenger vehicles equipped with automatic transmissions were produced with an improperly manufactured transmission parking rod. When the transmission selector lever is placed in the "p" (park) position, the transmission park mechanism, that is intended to hold your vehicle, may not engage.
Engine: cooling system
Risk: In some instances, the interference fit between the inner wall of the pulley center hole and the water pump drive shaft was not as tight as specified in the drawing specification. This could result in the water pump pulley dislodging from the water pump shaft, which can cause severe engine damage/seizure during vehicle usage.
Fix: Dealers will replace the water pump. Owner notification began september 12, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact subaru at 1-800-782-2783.
Full defect summary
On certain sport utility and passenger vehicles equipped with 4-cylinder engines, the water pump pulley center hole was improperly machined.
Recall repairs are free at any franchised dealer. Enter your VIN at nhtsa.gov/recalls to see which recalls are still open on your car.
NHTSA defect investigations
Air bag inflator rupture
Summary
The office of defects investigation (odi) opened pe14-016 in june 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.all six vehicles were operated in florida or puerto rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by takata, a tier-one supplier of automotive air bag systems.during the course of pe14-016, odi determined that five additional vehicle manufacturers used inflators of a similar design and vintage also supplied by takata. No evidence of field failures was found in vehicles produced by these five additional manufacturers.nonetheless, at odi's in
Air bag inflator rupture
Summary
The office of defects investigation (odi) opened pe14-016 in june 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.all six vehicles were operated in florida or puerto rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by takata, a tier-one supplier of automotive air bag systems.during the course of pe14-016, odi determined that five additional vehicle manufacturers used inflators of a similar design and vintage also supplied by takata. No evidence of field failures was found in vehicles produced by these five additional manufacturers.nonetheless, at odi's in
Questions about the 2003 Subaru Baja
- What are the most common problems with the 2003 Subaru Baja?
- By NHTSA owner complaints: brakes (8 complaints, typically around 8,000 miles); transmission (7 complaints, typically around 12,000 miles); engine (6 complaints).
- How many recalls does the 2003 Subaru Baja have?
- 10 recalls listed by NHTSA, the latest from January 2, 2020 (air bags). Check your VIN at nhtsa.gov/recalls to see which ones are still open on your car.
- Is the 2003 a bad year for the Subaru Baja?
- It is the most complained-about Baja model year since 2000, with 38 complaints. Complaint counts are not adjusted for how many cars were sold, so popular years collect more of them, and the newest years have had less time to.
Other Subaru Baja years
- 2003
- 2005