KnownCarProblems2007 Suzuki XL7 Problems and Recalls
Owners filed 138 complaints with NHTSA about the 2007 Suzuki XL7, most often about the fuel system (23% of complaints, typically around 112,500 miles). It is the most complained-about XL7 model year since 2000 and has 2 recalls.
Most common 2007 Suzuki XL7 problems
Fuel system
31 complaints · 23%Half of these problems showed up before 112,500 miles. Parts named most often: delivery.
My vehicle had the initial issue of the gas leak one week after purchase. My heat stopped working in 2010 and now when the car is stopped for gas, it won't restart normally, have to twist the key in the ignition several times before the vehicle starts. The engine light stays on and no one seems to know how to get it…
This vehicle should be recalled. It is a lemon!! I bought my Suzuki 2 years ago used and have had nothing but problems. I have had the timing chain replaced. After I get gas it sputters and struggles starting. The traction control light comes on and the engine power is reduced. Eventually it just stops running. I…
Engine
29 complaints · 21%Half of these problems showed up before 82,000 miles. Parts named most often: engine, cooling system, exhaust system.
Have had vehicle three years. Now they say the engine is gone and needs replaced but is not under warranty because I have too few oil change receipts. This night impossible to keep everyone of them considering I drive a good ways every day. Any documentation should be enough for the warranty. It is a scam by crooked…
Engine trouble light came on nov. 2009. Talked to dealership they said the light had to be on at time of comp. Diagnostic. Came on again in dec. 2009. Had diagnostic done at dealer & independently, the code indicated a cylinder misfire. The dealership ordered parts, which took two months to get (feb. 2010). In the…
Air bags
28 complaints · 20%Half of these problems showed up before 79,000 miles. Parts named most often: side/window, frontal, sensor.
Wednesday, 2-1-12 at approximately 1:20 central time I was driving 30-40 MPH range north on 132nd st. Just passed eagle run drive on a clear day that was sunny and in the lower 60's, my side impact curtain air bags on both sides deployed in all three rows. I do not think I hit a bump or swerved my wheel but do know I…
The airbag light on the passenger seat is illuminating when occupied. According to Suzuki the sensing unit are defective and need to replaced. 2007 Suzuki XL7 air bags service bulletin 276881 NHTSA: action number: 10032752 service bulletin number: 276881 see report date: dec 01, 2009component: air bags summary…
Steering
28 complaints · 20%Half of these problems showed up before 60,000 miles. Parts named most often: column.
It is a shame this vehicle has not been recalled for any of the problems we have encountered. 1. Steering wheel is difficult to turn at slow speeds and makes loud rubbing noise. 2. Door locks will not unlock using key fob. Have to manually unlock by hand from the inside. I consider this a danger. 3. Vehicle will not…
I am the owner of a 2007 Suzuki XL7 and have noticed a noise coming from the steering wheel. I researched this on the internet and found that dealerships are stating this is the steering rack problem. My vehicle currently has approximately 60k miles so it is out of warranty. I have owned several vehicles with high…
Electrical
20 complaints · 14%Half of these problems showed up before 59,000 miles. Parts named most often: horn, instrument cluster/panel.
It is a shame this vehicle has not been recalled for any of the problems we have encountered. 1. Steering wheel is difficult to turn at slow speeds and makes loud rubbing noise. 2. Door locks will not unlock using key fob. Have to manually unlock by hand from the inside. I consider this a danger. 3. Vehicle will not…
The engine overheated due to wiring shorting out on two fan motors. No fuse was tripped or light came on. Both motors shorted causing the connectors in the wiring harness to melt. Melting was discovered by local dealer. The wiring is being removed. I have pictures and I have documented the problem. The parts being…
Transmission
10 complaints · 7%Half of these problems showed up before 74,000 miles. Parts named most often: automatic transmission.
I'm the original owner of the 2007 XL7. I purchased my vehicle in july of 07 and I have had nothing but problems and countless repairs. I have to drive my car alot with 5 active children so I'm out of warranty. The first issue started with the electrical system at about 50k miles the system would shut down and lock…
The contact owns a 2007 Suzuki XL7. While driving approximately 20 MPH, the vehicle decelerated and the traction control indicator illuminated. The vehicle was towed to an independent mechanic who was unable to repair the vehicle. The vehicle was taken to an unknown service center where a diagnostic test was performed…
Visibility and wipers
8 complaints · 6%Half of these problems showed up before 50,000 miles. Parts named most often: sun/moon roof assembly, windshield wiper/washer, power window devices and controls, windshield.
I'm the original owner of the 2007 XL7. I purchased my vehicle in july of 07 and I have had nothing but problems and countless repairs. I have to drive my car alot with 5 active children so I'm out of warranty. The first issue started with the electrical system at about 50k miles the system would shut down and lock…
I purchased my XL7 new from shortline Suzuki in 2009. It has 43,000 miles on it and it has developed a noise in the steering column, I had the dealership check the issue and was told the steering rack needed replacement, I have driven this vehicle for only 2 years!! This is a defect, not an isolated incident, as many…
Stability control
8 complaints · 6%Half of these problems showed up before 101,500 miles.
Traction control system comes on vehicle slows down and wheels stop spinning, braking system becomes stiff, there seems to be a change in motor sounds when this happens. This has to be a manufacturer defect in this vehicle.
This vehicle should be recalled. It is a lemon!! I bought my Suzuki 2 years ago used and have had nothing but problems. I have had the timing chain replaced. After I get gas it sputters and struggles starting. The traction control light comes on and the engine power is reduced. Eventually it just stops running. I…
Complaints are owner reports to NHTSA, not verified defects. One complaint can name several components, so shares add up to more than 100%.
2007 Suzuki XL7 recalls
Fuel system: fuel pump
Risk: Fuel leakage in the presence of an ignition source may result in a fire.
Fix: American suzuki will notify owners, and dealers will replace the fuel pump module, free of charge. An interim letter was mailed on march 7, 2013. Owners may contact american suzuki customer relations at 1-800-934-0934.
Full defect summary
American suzuki is recalling certain model year 2007 xl-7 vehicles originally sold or currently registered in arizona, california, nevada, and texas; and manufactured june 13, 2006, through december 22, 2006. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.
Visibility and wipers: windshield
Risk: In the event of a crash, the windshield may not be retained to the extent required by the standard, increasing the risk of personal injuries to the vehicle occupants.
Fix: Dealers will inspect and replace any glass (windshield, liftgate glass, or the side stationary glass) that was installed incorrectly.the recall began on july 10, 2007. Owners may contact suzuki at 1-800-934-0934.
Full defect summary
Certain vehicles fail to conform to the requirements of federal motor vehicle safety standard no. 212, "windshield mounting." an incorrect primer may have been used when installing the windshield.
Recall repairs are free at any franchised dealer. Enter your VIN at nhtsa.gov/recalls to see which recalls are still open on your car.
Questions about the 2007 Suzuki XL7
- What are the most common problems with the 2007 Suzuki XL7?
- By NHTSA owner complaints: fuel system (31 complaints, typically around 112,500 miles); engine (29 complaints, typically around 82,000 miles); air bags (28 complaints, typically around 79,000 miles).
- How many recalls does the 2007 Suzuki XL7 have?
- 2 recalls listed by NHTSA, the latest from December 20, 2012 (fuel system). Check your VIN at nhtsa.gov/recalls to see which ones are still open on your car.
- Is the 2007 a bad year for the Suzuki XL7?
- It is the most complained-about XL7 model year since 2000, with 138 complaints. Complaint counts are not adjusted for how many cars were sold, so popular years collect more of them, and the newest years have had less time to.