KnownCarProblems2009 Toyota RAV4 Problems and Recalls
Owners filed 327 complaints with NHTSA about the 2009 Toyota RAV4, most often about the speed control (30% of complaints, typically around 11,000 miles). It is 10th of 26 RAV4 model years by number of complaints and has 15 recalls.
Most common 2009 Toyota RAV4 problems
Speed control
99 complaints · 30%Half of these problems showed up before 11,000 miles. Parts named most often: accelerator pedal.
Currently, I own a 2009 RAV4 that was not apart of the recall due to the fact the car was manufactured in japan. However, I am experiencing sudden acceleration in my vehicle and Toyota is doing nothing to resolve this issue. On a daily basis when I drive the car and I am pressing on the accelerator pedal the car…
I have a 2009 Toyota RAV4 that has unexpectedly accelerated 3 times. When I tried to brake the pedal was hard and the car accelerated. I threw it in neutral and took my foot off the brake. The car didn't rev like the pedal was stuck, instead it calmed down and came under control. Dealer says they can't find anything…
Suspension
55 complaints · 17%Half of these problems showed up before 65,500 miles. Parts named most often: front.
I brought my 2009 Toyota rav 4 into the romano Toyota (6400 basile rowe east syracuse, ny 13057) service department after receiving a recall notice for possible rusting in the rear suspension bar. The service department assured me that they had thoroughly checked the recalled part, and everything was fine. 5 months…
The contact owns a 2009 Toyota rav 4. The contact stated while driving at 65 MPH, the vehicle started to make popping noises and started to spin out of control. The vehicle was towed to an independent mechanic. The technician diagnosed that the rear lower arm tie rod had fractured. The contact had received a recall…
Engine
35 complaints · 11%Half of these problems showed up before 38,500 miles. Parts named most often: engine, cooling system.
The brake was engaged in traffic when the car started to accelerate. I applied the brake more firmly and put the car in park. The engine began to rev uncontrollably in a cloud of white smoke. I switched the car off and restarted the motor and it then ran normally.
Vehicle was parked overnight on our front driveway facing the garage. Where it always parked everyday. The weather was warm and clear my wife was in the vehicle and was preparing to buckle up and drive to church, I entered the vehicle into the passenger seat and buckled up. She started the vehicle and immediately…
Brakes
30 complaints · 9%Half of these problems showed up before 21,500 miles. Parts named most often: pedals and linkages, foundation components.
The contact owns a 2009 Toyota RAV4. The contact stated that he received a notice from the manufacturer stating that in the event that the vehicle would possibly accelerate abnormally, that the brakes should be applied with the force of two feet to prevent incident. The contact stated that he believed the failure was…
I have ha the car back to the dealer for this brake problem and they said this is normal ,what the problem is the brake pedal is soft and when braking you foot can hit the gas pedal this also the pedal will go down when you are holding at a stop,also its not leaking brake fluid as the car was service at the dealer.
Transmission
28 complaints · 9%Half of these problems showed up before 78,500 miles. Parts named most often: automatic transmission, driveline.
On may 20, 2015 my 2009 rav 4 developed a whining noise in rear area that got louder the faster I went. Vehicle has 78,385 miles on it and is just out of warranty. Took to dealer and was told that it was the viscous coupler assembly that needed to be replaced at a cost of $1,806.75. I mentioned the service bulletin…
I purchased a used 2009 RAV4 with about 78,000 miles. It was a one owner with a clean car fax. It was great during the test drive. About 2 days after I purchased it, it started to make a rattle/rumble/vibration at approximately 40mph and 1500 - 1800rpm. It seems like the noise was coming from the…
Steering
26 complaints · 8%Half of these problems showed up before 50,000 miles. Parts named most often: linkages.
When turning the steering wheel either direction at low speeds a clunking noise was audible. Car has only 50,000 miles. Looked on internet and found hundreds of reports of the problem in multiple models and over many years. The cause is the steering column shaft. Took it to dealer and that was exactly the problem!…
Steering started creating occasional mild noise while turning at around 49000. At 53000 during maintenance service at burlington Toyota, ontario I reported this incident along with a metallic noise when the brake pedal is pressed. They mentioned not to be able to reproduce the problem and hence did not make any fix.…
Other or unspecified
21 complaints · 6%Half of these problems showed up before 65,500 miles.
While my wife was driving on the highway at 60 MPH the engine lost power. Moving to the right lane to pull over, flames began coming out of the top of the hood, hitting the windshield. She tried stopping but brake pedal went to the floor, requiring her to put the car in park and slide on grass. She jumped out of the…
Was driving,sudden lost p/s, all lights on dash came on, determined fuse ecu-ig1, blown, determined, when rear view mirror disconn. The fuse doesn't blow.tsb:ig1 relay needs 2b updated $1,000+ vehicle was in motion on a county street.....updated 12/03/15
Electrical
19 complaints · 6%Half of these problems showed up before 34,000 miles. Parts named most often: wiring.
While stopped at red light with right foot on brake, engine suddenly accelerated to very high RPM. Shifted to neutral and engine revved even higher. Turned off ignition. Signal turned green and since I was in traffic, decided to try to start engine again. Engine started and performed normally. Immediately drove to…
I was driving up my driveway, applied the brakes and did not stop, but was forced forward until I hit my house. I searched for the brakes but could not find them, because the brakes were stuck to the floor. There was no brake light on. Before that the odometer was jumping between numbers (20,17, 54, ect.). I had my…
Complaints are owner reports to NHTSA, not verified defects. One complaint can name several components, so shares add up to more than 100%.
2009 Toyota RAV4 recalls
Suspension: rear
Risk: Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Fix: Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on september 30, 2016. Owners may contact toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are g0v for toyota vehicles and glk for lexus vehicles. Note: this recall supersedes recall 13v-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13v-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to h
Full defect summary
Toyota motor engineering & manufacturing (toyota) is recalling certain model year 2006-2011 toyota rav4 vehicles manufactured october 31, 2005, to september 7, 2010, and 2010 lexus hs250h vehicles manufactured july 6, 2009, to august 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle's alignment.
Seats: seat heater/cooler
Risk: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Fix: Set will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on july 14, 2016. Owners may contact set customer service at 1-866-405-4226. Set number for this recall is set16b.
Full defect summary
Southeast toyota distributors, llc (set) is recalling certain 2005-2011 4runner, highlander, sequoia, and sienna, 2005-2010 avalon and tundra, 2006-2008 camry solara, 2006-2010 highlander hybrid, 2006-2011 rav4 and tacoma, 2007-2010 fj cruiser, 2007-2011 camry hybrid, 2009-2010 venza, 2010-2012 prius, 1988-1990 and 2005-2010 camry, and 1989 and 2009-2010 corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Seat belts: rear/other
Risk: A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.
Fix: Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on june 24, 2016. Owners may contact toyota customer service at 1-800-331-4331. Toyota's number for this recall is g0f.
Full defect summary
Toyota motor engineering & manufacturing (toyota) is recalling certain model year 2006-2012 rav4 vehicles manufactured july 28, 2005, to december 19, 2012, and 2012-2014 rav4 EV vehicles manufactured july 24, 2012, to august 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.
Visibility and wipers: power window devices and controls
Risk: If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Fix: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the pwms circuit board will be replaced, free of charge. The recall is expected to begin december 20, 2015. Owners may contact toyota customer service at 1-800-331-4331. Toyota's number for this recall is c0m.
Full defect summary
Toyota motor company (toyota) is recalling certain model year 2009-2011 tundra, sequoia, corolla, corolla matrix and scion xb, 2008-2011 highlander and highlander hybrid, 2007 camry and camry hybrid, 2009 camry and camry hybrid, 2006-2011 rav4, 2006-2010 yaris, and 2009-2010 scion xd and pontiac vibe vehicles. During the manufacturing of the power window master switch (pwms), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
Visibility and wipers: visibility/wiper
Risk: Over time, the dripping water may cause corrosion and wear at the joint, potentially resulting in the separation of the wiper linkage. Once this occurs, the wipers would not function, reducing driver visibility and increasing the risk of a crash.
Fix: Toyota will notify owners, and dealers will replace the water diverter channel. In addition, a new wiper linkage with a wiper motor crank arm will be installed. The wiper linkage will have a protective cover over the wiper linkage joint to minimize water splash and a retainer ring to prevent the wiper arm from separating from the wiper motor. The recall began on november 7, 2016. Owners may contact toyota's customer service number at 1-800-331-4331.
Full defect summary
Toyota motor engineering & manufacturing (toyota) is recalling certain model year 2009-2012 rav4 vehicles manufactured october 27, 2008, to december 19, 2012 and 2012-2014 rav4 EV vehicles manufactured july 24, 2012, to august 29, 2014. In the affected vehicles, water may drip onto the joint that connects the wiper linkage to the wiper motor.
Seats: seat heater/cooler
Risk: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Fix: Set will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in january 2015. Owners may contact set customer service at 1-866-405-4226.
Full defect summary
Southeast toyota distributors, llc (set) is recalling certain model year 2010-2011 prius and corolla, 2009-2011 venza, 2006-2010 avalon, 2007-2010 fj cruiser, 2005-2011 sienna and sequoia, 2006-2011 tacoma 4x2 and 4x4, camry, highlander, tundra 4x2 and 4x4, and 2007-2011 rav4 and 4runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Suspension: rear
Risk: Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Fix: Toyota will notify owners, and dealers will inspect the tie rods and replace any that have rust or corrosion on the alignment adjustment threads. All of the rear tie rods will then be encased in an epoxy to prevent future environmental damage. Due to limitations in parts, the recall remedy will be launched in phases from september 2013 through mid-april 2014. All owners will receive notification of the recall, with most receiving second notifications when parts are available in their area. Important: this recall supersedes toyota and lexus recall 12v-373. All vehicles that have been inspected
Full defect summary
Toyota is recalling certain model year 2006 through 2011 rav4 and 2010 lexus hs250h passenger vehicles manufactured from october 2005 through september 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Seats
Risk: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.
Fix: Southeast toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on march 21, 2013. Owners may contact southeast toyota at 1-800-301-6859.
Full defect summary
Southeast toyota distributors, llc (set) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 tacoma, 4runner, camry, camry hybrid, prius, and rav4; model year 2009-2010 avalon, fj cruiser, and highlander hybrid; model year 2010-2013 model year corolla, sienna and tundra; model year 2009-2013 highlander and venza; model year 2012 prius v; and model year 2010-2012 sequoia. During modification by set to include accessories such as leather seat covers, seat heaters or headrest dvd systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.
Visibility and wipers: power window devices and controls
Risk: If the switch overheats, it may melt, possibly resulting in a fire.
Fix: Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their toyota dealer or the toyota customer experience center at 1-800-331-4331. General motors will contact the pontiac vibe owners affected by this recall and gm dealers will inspect and repair switches as necessary. Those owners may contact pontiac customer care at 1-800-762-2737.
Full defect summary
Toyota is recalling certain model year 2007-2009 camry, camry hybrid, rav4, corolla, corolla matrix, tundra, sequoia, highlander, highlander hybrid, yaris, scion xb, scion xd and pontiac vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.
Suspension: rear
Risk: Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Fix: Toyota will notify owners, and dealers will inspect the rear tie-rod nut for looseness and replace any suspect tie-rod found loose. Dealers will also affix instructions in multiple places to prevent improper servicing in the future. The recall began on november 30, 2012. Owners may contact toyota at 1-800-331-4331 or lexus at 1-800-255-3987.
Full defect summary
Toyota is recalling certain model year 2006 through 2011 rav4 and 2010 lexus hs250h passenger vehicles manufactured from october 2005 through september 2010. If the nuts for adjusting the rear wheel alignment are improperly tightened during service, the rear suspension arm (rear tie rod) may develop unwanted movement and rust, leading to thread damage and eventual failure. Failure of the rear tie rod will cause an abrupt change in the vehicle's alignment.
Speed control: accelerator pedal
Risk: A stuck open accelerator pedal may result in very high vehicle speeds and make it difficult to stop the vehicle, which could cause a crash, serious injury or death.
Fix: The remedy is now available. The safety recall began early april 2011. The remedy will involve modification or replacement of the accelerator pedal and replacement of any toyota all-weather floor mat. Owners may contact toyota at 1-800-331-4331 or lexus at 1-800-255-3987.
Full defect summary
Toyota is recalling certain model year 2008 through 2011 lexus lx570, 2003 through 2009 toyota 4runner, and 2006 through 2010 rav4 vehicles. The accelerator pedal can get stuck in the wide open position due to its being trapped by an unsecured or incompatible driver's floor mat.
Equipment: labels
Risk: This does not meet the standard requirements.
Fix: Dealers will mail to consumers the corrected label or the customer will have the option for dealers to install the label free of charge. Dealers will also correct the owner's manual. The safety recall began on may 27, 2010. Owners may contact gulf states toyota at 713-580-3300.
Full defect summary
Gulf states toyota is recalling certain model year 2005-2010 vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims." these vehicles were sold between september 1, 2005 and june 2, 2008 without the requisite load carrying capacity modification labels.
Equipment: labels
Risk: A driver may overload a vehicle which may increase the risk of a crash.
Fix: Dealers will mail to consumers the corrected label or the customer will have the option for dealers to install the label free of charge. The safety recall began on may 27, 2010. Owners may contact southeast toyota at 1-800-301-6859.
Full defect summary
Southeast toyota is recalling certain model year 2005-2011 passenger vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims." these vehicles were sold without the requisite load carrying capacity modification labels.
Speed control: accelerator pedal
Risk: The accelerator pedal may become hard to depress, slow to return to idle, or, in the worst case, mechanically stuck in a partially depressed position, increasing the risk of a crash.
Fix: Dealers will install a reinforcement bar in the accelerator pedal which will allow the pedal to operate smoothly. Gm will notify owners for the pontiac vibe please see 10v-018. This service will be performed free of charge. The safety recall is expected to begin on february 5, 2010 and will be completed on march 15, 2010. Owners may contact toyota at 1-800-331-4331.
Full defect summary
Toyota is recalling certain model year 2005-2010 avalon, model year 2007-2010 camry, model year 2009-2010 corolla, corolla matrix, rav4, model year 2010 highlander, model year 2008-2010 sequoia, and model year 2007-2010 tundra vehicles. Due to the manner in which the friction lever interacts with the sliding surface of the accelerator pedal inside the pedal sensor assembly, the sliding surface of the lever may become smooth during vehicle operation. In this condition, if condensation occurs on the surface, as may occur from heater operation (without A/C) when the pedal assembly is cold, the friction when the accelerator pedal is operated may increase, which may result in the accelerator pedal becoming harder to depress, slower to return, or, in the worst case, mechanically stuck in a partially depressed position.
Equipment: labels
Risk: Incorrect load carrying capacity modification labels could result in the vehicle being overloaded, increasing the risk of a crash.
Fix: Toyota will notify owners and provide them with a new, accurate label to be installed over the inaccurate label free of charge. The safety recall began on august 18, 2009. Owners may contact toyota at 1-888-270-9371.
Full defect summary
Toyota is recalling 27,080 model year 2005 through 2010 passenger cars built from september 1, 2005 to may 4, 2009. These vehicles were not equipped with load carrying capacity modification labels which fails to conform with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims."
Recall repairs are free at any franchised dealer. Enter your VIN at nhtsa.gov/recalls to see which recalls are still open on your car.
NHTSA defect investigations
Power window master switch fire
Summary
On october 10, 2012, toyota initiated a safety recall of approximately 2.5 million u.s. Vehicles involving the following models and model years:2007-2009 camry and camry hybrid, 2009 corolla and corolla matrix, 2008 highlander and highlander hybrid, 2007-2009 rav4, 2008-2009 scion xb and xd, 2008-2009 sequoia, 2007-2008 tundra, 2007-2008 yaris, and 2009 pontiac vibe.see NHTSA recall number 12v-491 for more details, including the affected vehicle manufacture dates for each vehicle model.note that only early-production 2009 model year vehicles are included in the recall.toyota and gm dealers will inspect the power window master switch (pwms) assemblies and apply a specialized grease that inhib
Power window master switch fire
Summary
Odi has identified certain toyota vehicles experiencing a higher rate of fire and thermal event incidents among all toyota vehicles that use the same power window master switch design.they include a total of approximately 1.4 million model year (my) 2007 through 2009 camry, camry hybrid, rav4 and yaris vehicles built from approximately september 2006 through august 2008, as well as all my 2008 highlander hybrid vehicles.this preliminary evaluation has been upgraded to an engineering analysis (ea12-006) to further study the alleged defect and its consequences.the odi reports cited above can be viewed at www-odi.NHTSA.dot.gov/owners/searchnhtsaid under the following identification numbers: 104
Unintended and uncontrolled acceleration
Summary
On february 16, 2010, NHTSA's office of defects investigation (odi) opened rq10-003 to determine whether the scope of prior toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, toyota recalls 07e-082, 09v-388, 10v-017, and 10v-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in toyota and lexus vehicles.I. Pedal interference from floor mats, carpet covers and plastic pads in carpets.during the rq10-003 investigation, odi reviewed a large volume of documents to assess whether additional vehicles should be recalled.following the agency's analysis, NHTSA requested that toyota recall ad
Questions about the 2009 Toyota RAV4
- What are the most common problems with the 2009 Toyota RAV4?
- By NHTSA owner complaints: speed control (99 complaints, typically around 11,000 miles); suspension (55 complaints, typically around 65,500 miles); engine (35 complaints, typically around 38,500 miles).
- How many recalls does the 2009 Toyota RAV4 have?
- 15 recalls listed by NHTSA, the latest from August 12, 2016 (suspension). Check your VIN at nhtsa.gov/recalls to see which ones are still open on your car.
- Is the 2009 a bad year for the Toyota RAV4?
- It is 10th of 26 RAV4 model years by number of complaints, with 327 complaints. Complaint counts are not adjusted for how many cars were sold, so popular years collect more of them, and the newest years have had less time to.