KnownCarProblems2007 Volvo S40 Problems and Recalls
Owners filed 25 complaints with NHTSA about the 2007 Volvo S40, most often about the engine (20% of complaints). It is 7th of 12 S40 model years by number of complaints and has 2 recalls.
Most common 2007 Volvo S40 problems
Engine
5 complaints · 20%Parts named most often: cooling system.
I own a '07 Volvo S40 with 78,000 miles. It began making a loud whistling noise coming from the oil dipstick. After researching online I found that it was a known problem by Volvo and the defective part is covered under an extended warranty, however this defective part causes excessive damage to the engine that is not…
The contact owns a 2007 Volvo S40. While driving, there was an abnormal noise coming from the engine and the check engine warning light illuminated. The vehicle was taken to an independent mechanic who diagnosed that the pvc valve failed. The vehicle was not repaired. The manufacturer was notified of the failure. The…
Brakes
5 complaints · 20%Half of these problems showed up before 63,000 miles. Parts named most often: foundation components.
Tl contact owns a 2007 Volvo S40. The contact stated that while driving approximately 30 MPH the brakes failed causing her to crash into the rear of a vehicle. The driver sustained minor injuries, whiplash and was not transported to the hospital. A police report was filed. The vehicle was inspected by an insurance…
The contact owns a 2007 Volvo S40. The contact stated that the brake sensor illuminated indicating low brake fluid. The vehicle was taken to an authorized dealer. The technician replenished the brake fluid and reset the brake sensor. The contact indicated that shortly after the brake sensor was reset by the dealer…
Electrical
5 complaints · 20%Half of these problems showed up before 70,000 miles. Parts named most often: ignition.
I parked the 2007 S40 Volvo and can't remove the key from the ignition switch. The car is in park, brake on, all necessary checks are checked. Still can't get the key to release, had to turn it several times (30 minutes) right to left until I heard a click and the key came out. I have seem post on the internet about…
Sunroof drain became clogged. This caused the poorly designed drains to leak at a junction inside the vehicle along the door pillar and behind the instrument panel. The water collects on the rear passenger floorboards and around the drivers seat. The car owner is unaware of the leak until a large amount of water has…
Other or unspecified
3 complaints · 12%Safety concern: 2007 Volvo S40 electronic throttle module failure - causing "reduced engine performance" message and vehicle (2007 Volvo S40) suddenly slows down while in motion, limps and cannot go higher speed. Had barely exited the freeway on 1/24/2017 and this happened as I was on ramp. Could be extremely…
After parking car and turning car off, airbag, brake, and information warning lights stay on, as does ventilation system. Passenger seat has excess water underneath. Now car will not start.
Complaints are owner reports to NHTSA, not verified defects. One complaint can name several components, so shares add up to more than 100%.
2007 Volvo S40 recalls
Equipment: navigational system(global positioning system)
Risk: An overheated battery could lead to a fire.
Fix: Volvo advises owners to please stop using the garmin portable GPS device immediately, and visit the garmin website to determine if their unit is affected. The unit's battery will be replaced with a new battery and a spacer will be inserted on top of the battery next to the pcb. This service will be performed free of charge. The safety recall began on november 18, 2010. Owners may contact garmin at 866-957-1981 or visit garmin's website at www.garmin.com/nuvibatterypcbrecall.
Full defect summary
Volvo is recalling certain vehicles equipped with garmin 760 portable global positioning system (GPS) units because the batteries on those units may overheat.
Brakes: master cylinder
Risk: The capacity to brake will gradually deteriorate forcing the driver to use a higher than expected force on the brake pedal when compared to an intact brake system. The deterioration can eventually result in complete loss of the brake system functionality increasing the risk of a crash.
Fix: Dealers will inspect the master cylinder. The brake master cylinder and brake fluid reservoir will be replaced and certain brake lines cleaned free of charge. The recall began on march 11, 2008. Owners may contact volvo at 1-800-458-1552.
Full defect summary
Volvo is recalling 1,114 my 2007 c30, c70, s40, and v50 passenger vehicles. A soft anodized layer in the master cylinder may trigger early wear on a rubber seal that can result in internal leakage of brake fluid. If affected, the driver may experience reduced brake performance when applying and maintaining force of the brake pedal.
Recall repairs are free at any franchised dealer. Enter your VIN at nhtsa.gov/recalls to see which recalls are still open on your car.
Questions about the 2007 Volvo S40
- What are the most common problems with the 2007 Volvo S40?
- By NHTSA owner complaints: engine (5 complaints); brakes (5 complaints, typically around 63,000 miles); electrical (5 complaints, typically around 70,000 miles).
- How many recalls does the 2007 Volvo S40 have?
- 2 recalls listed by NHTSA, the latest from November 8, 2010 (equipment). Check your VIN at nhtsa.gov/recalls to see which ones are still open on your car.
- Is the 2007 a bad year for the Volvo S40?
- It is 7th of 12 S40 model years by number of complaints, with 25 complaints. Complaint counts are not adjusted for how many cars were sold, so popular years collect more of them, and the newest years have had less time to.