KnownCarProblemsHome › Subaru › Outback › 2005
2005 Subaru Outback Problems and Recalls
Owners filed 273 complaints with NHTSA about the 2005 Subaru Outback, most often about the suspension (21% of complaints, typically around 60,500 miles). It is 14th of 27 Outback model years by number of complaints and has 9 recalls.
Most common 2005 Subaru Outback problems
Suspension
56 complaints · 21%Half of these problems showed up before 60,500 miles. Parts named most often: rear, front.
2005 Subaru Outback sedan driven on icy/snowy road conditions experiences extreme slippage in the rear of the car. Have experienced this on at least two other occasions with this vehicle in similar conditions. Awd does not appear to be keeping the rear of the car on the road or in line. Vehicle fishtails or ghostwalks…
I have experienced what is referred to as "ghostwalking" in my 2005 Subaru Outback. While driving in winter conditions such as slush, snow and ice mix, and black ice the car fishtails in the rear wheels making it impossible to safely drive this car. However driving on hardpack snow and hardpack powder the car handles…
Speed control
40 complaints · 15%Half of these problems showed up before 89,500 miles. Parts named most often: cruise control, accelerator pedal, throttle.
From an intersection, I slowed down to make a right turn and upon completing the turn, I put my foot on the gas pedal to accelerate and the pedal was unresponsive. I had enough momentum to quickly turn onto a side street out of traffic. The gas pedal when pushed down all the way would not accelerate and did not make…
I have been having a problem with my car for the 2-years and has been getting worse. The throttle pedal at times will become non-responsive and the engine idle cannot be controlled. At this time the check engine light is on with a code. P2138. I have taken the car to the dealer with no luck they could not find…
Air bags
38 complaints · 14%Half of these problems showed up before 67,500 miles. Parts named most often: frontal.
In 2008 the airbags on our car deployed spontaneously while driving down the interstate. Before the airbags deployed the seatbelt lights in our car began dinging and flashing as if someone were in the passenger seat, which was empty, and then they deployed on my husband. After 3 or so months Subaru had the airbag…
The contact owns a 2005 Subaru Outback. The contact stated that he had experienced a failure related the manufacturer's takata air bag recall. The specifics of the failure experienced were not available. The contact stated that the VIN was not included in the manufacturer's takata air bag recall. The approximate…
Brakes
31 complaints · 11%Half of these problems showed up before 165,000 miles. Parts named most often: foundation components, antilock/traction control/electronic limited slip.
4way connector brake line leaking causing no brakes. Could of got in serious accident hazzard to drive called about recall on this but the said my car VIN number was not listed and we're very rude and she hung up on me. Had to put car in nutral to slow diwn
The vehicle has soft brakes, it is common among this generation. It does not matter if everything is replaced. There is still a long/soft pedal travel. This may be due to an inadequate master cylinder size or brake booster size. This is a constant issue, does not matter when you use the brakes, it always is slow to…
Lights
30 complaints · 11%Half of these problems showed up before 66,500 miles. Parts named most often: headlights.
We purchased a used 2005 Subaru Outback ltd. Wagon in august of 2008 and almost immediately had to replace the left front driver's low beam headlight bulb. Since that time, we have replaced 3 more left side headlight low beam bulbs and 2 right side low beam headlight bulbs. Subaru tells US there are no issues with…
Driving at night. Stopped to get gas. Went to start car and turn on lights. Both headlights out-just like that. Had to drive home on running lights; luckily less than 5 miles. Headlight issues started about 10k miles ago where individual lights have gone out; have replaced ind low beam lights 4x in the last 10k miles.…
Electrical
28 complaints · 10%Half of these problems showed up before 111,000 miles. Parts named most often: 12v/24v/48v battery, alternator/generator/regulator.
Subaru Outback 2005: the wire harness to the rear tailgate failed and shorted out the brake lights and reverse lights, creating a safety hazard while driving.
Just after getting off I-43 near sheboygan on frontage road my car lost all power and no acceleration on gas pedal. Check engine light came on and cruise control light was blinking. I had to shift to neutral and pull over to a shoulder. Turned the car off for couple of minutes while I check under the hood. Started the…
Engine
26 complaints · 10%Half of these problems showed up before 85,000 miles. Parts named most often: engine, exhaust system.
At approximately 85,000 miles, the check engine light on our 2005 Subaru Outback xt went on and we took the vehicle in to our local repair shop to check the light and they recommended having the vehicle towed to our Subaru dealer. The vehicle was towed in and the dealer service person called stating that timthe turbo…
I have been having a problem with my car for the 2-years and has been getting worse. The throttle pedal at times will become non-responsive and the engine idle cannot be controlled. At this time the check engine light is on with a code. P2138. I have taken the car to the dealer with no luck they could not find…
Fuel system
19 complaints · 7%Half of these problems showed up before 123,000 miles.
The contact owns a 2005 Subaru Outback. The contact stated that when driving the vehicle he noticed an overpowering smell of gas. Once he inspected the vehicle, he noticed that there was a leak near the fuel tank. The vehicle was taken to an independent mechanic where they advised him that the fuel tank was fractured…
I was attempting to accelerate from a stop light and my Outback acted as though I took my foot off the accelerator. The more I attempted to accelerate the less it responded. If the oncoming traffic hadn't noticed, they would have hit me. When I finally got it off the road and shut if off for awhile, it started but…
Complaints are owner reports to NHTSA, not verified defects. One complaint can name several components, so shares add up to more than 100%.
2005 Subaru Outback recalls
Air bags: inflator module
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Fix: Subaru will notify their owners. General motors will notify saab owners. Dealers will replace the passenger air bag inflators, free of charge. The recall began january 7, 2020. Subaru owners may contact subaru customer service at 1-844-373-6614. Saab owners may contact the saab customer assistance center at 1-800-955-9007. Subaru's number for this recall is tkb-20.
Full defect summary
Subaru of america, inc. (subaru) is recalling certain 2009-2013 forester, 2003-2006 baja, 2004-2011 impreza, 2004-2014 wrx (including sti), 2003-2014 legacy and outback, and 2006 saab 9-2x vehicles originally sold, or ever registered, in the states of arizona, arkansas, delaware, district of columbia, illinois, indiana, kansas, kentucky, maryland, missouri, nebraska, nevada, new jersey, new mexico, north carolina, ohio, oklahoma, pennsylvania, tennessee, virginia, and west virginia or "zone b." these vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Air bags: inflator module
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Fix: Subaru will notify their owners. General motors will notify saab owners. Dealers will replace the passenger air bag inflators with alternate inflators, free of charge. The recall began january 7, 2020. Subaru owners may contact subaru customer service at 1-844-373-6614. Saab owners may contact the saab customer assistance center at 1-800-955-9007. Subaru's number for this recall is tka-20.
Full defect summary
Subaru of america, inc. (subaru) is recalling certain 2009-2013 forester, 2003-2006 baja, 2004-2011 impreza, 2004-2014 wrx (sti included), 2003-2014 legacy and outback, and 2005-2006 saab 9-2x vehicles originally sold, or ever registered, in the states of alabama, california, florida, georgia, hawaii, louisiana, mississippi, south carolina, texas, puerto rico, american samoa, guam, the northern mariana islands (saipan), and the u.s. Virgin islands or "zone a." these vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Air bags: inflator module
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Fix: Subaru will notify their owners. General motors will notify saab owners. Dealers will replace the passenger air bag inflators, free of charge. The recall began january 7, 2020. Subaru owners may contact subaru customer service at 1-844-373-6614. Saab owners may contact the saab customer assistance center at 1-800-955-9007. Subaru's number for this recall is tkc-20.
Full defect summary
Subaru of america, inc. (subaru) is recalling certain 2009-2013 forester, 2003-2006 baja, 2004-2011 impreza, 2004-2014 wrx (including sti), 2003-2014 legacy and outback, and 2005-2006 saab 9-2x vehicles originally sold, or ever registered, in the states of alaska, colorado, connecticut, idaho, iowa, maine, massachusetts, michigan, minnesota, montana, new hampshire, new york, north dakota, oregon, rhode island, south dakota, utah, vermont, washington, wisconsin, and wyoming or "zone c." these vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Electrical: switch
Risk: The engine turning off unexpectedly can increase the risk of a crash. If a crash occurs under this condition, the air bag may not deploy, increasing the risk of injury.
Fix: Subaru will notify owners, and dealers will inspect the ignition switch, replacing the ignition switch, if necessary, free of charge. The recall began may 10, 2019. Owners may contact subaru customer service at 1-844-373-6614. Subaru's number for this recall is wuf-91.
Full defect summary
Subaru of america, inc. (subaru) is recalling certain 2009-2013 forester vehicles, 2008-2011 impreza vehicles, 2008-2014 wrx vehicles, 2005-2014 legacy vehicles, 2005-2014 outback vehicles and 2006-2008 tribeca vehicles equipped with a mechanical key ignition switch installed as a replacement part. The ball spring inside the switch may break, reducing the strength of the ignition switch. If this occurs, the weight on the key ring and certain road conditions could cause the ignition switch to move out of the run position to the accessory position, turning off the engine.
Air bags: inflator module
Risk: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Fix: Subaru will notify their owners and general motors will notify saab owners. Dealers will replace the passenger air bag inflator, free of charge. The subaru recall began on june 17, 2015. Owners may contact subaru customer service at 1-800-782-2783. The saab recall began on july 27, 2015. Owners of saab vehicles may call 1-800-955-9007. Subaru's number for this recall is wqr-53. Note: the recall completely supersedes recall 14v-399 (wql-48) and partially supersedes recall 14v-763 (wqp-51) in that model year 2004 through 2005 subaru impreza and model year 2005 saab 9-2x vehicles are now only par
Full defect summary
Subaru of america, inc. (subaru) is recalling certain model year 2003-2004 subaru baja vehicles manufactured january 22, 2003, to july 21, 2004, 2004-2005 impreza vehicles manufactured january 28, 2003, to may 31, 2005, 2003-2008 subaru legacy vehicles manufactured january 22, 2003, to may 2, 2008, 2003-2008 subaru outback vehicles manufactured february 18, 2003, to may 5, 2008, and 2005 saab 9-2x vehicles manufactured february 11, 2004, to march 17, 2005. The affected vehicles are equipped with a passenger side frontal air bag that may be susceptible to moisture intrusion which, over time, could cause the inflator to rupture upon its deployment.
Air bags
Risk: In the event of a crash necessitating deployment of the passengerâs frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Fix: Subaru will notify their owners. Dealers will replace the passenger air bag inflator, free of charge. The recall began on january 15, 2015. Owners may contact subaru at 1-800-782-2783. Subaru's number for this recall is wqp-51. Note: this recall supersedes recall 14v-471. This recall has been partially superseded by 15v-323. All 2005 model year subaru legacy and outback vehicles will now be repaired under recall 15v-323.
Full defect summary
Subaru of america, inc. (subaru) is recalling certain model year 2003-2004 legacy and outback vehicles, and 2003-2005 baja vehicles sold, or ever registered, in geographic locations associated with high absolute humidity. Specifically, vehicles sold, or ever registered, in puerto rico, hawaii, the u.s. Virgin islands, guam, saipan, american samoa, florida and adjacent counties in southern georgia, as well as the coastal areas of alabama, louisiana, mississippi and texas. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to rupture.
Brakes: hoses, lines/piping, and fittings
Risk: Brake line corrosion may result in brake fluid leakage. Fluid leakage may result in longer distances being required to slow or stop the vehicle, increasing the risk of a crash.
Fix: Subaru will notify owners, and dealers will test the brake system by depressing the brake pedal and inspecting for brake fluid leaks. If no brake fluid seepage is observed, the affected areas will be rustproofed with anti-corrosion wax. If brake fluid seepage is observed, the brake lines will be replaced followed by rustproofing with anti-corrosion wax. These services will be performed free of charge. The recall began july 2014 and second notifications will run through november 2014. Owners may contact subaru at 1-800-782-2783. Subaru's recall campaign number is wqk-47. Note: this recall super
Full defect summary
Subaru of america, inc. (subaru) is recalling certain model year 2005-2009 outback and legacy, 2008-2011 impreza and 2008-2014 impreza wrx/sti, and 2009-2013 forester vehicles, currently, or formerly, registered in connecticut, delaware, illinois, indiana, iowa, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, wisconsin and the district of columbia. Salt water could splash on the brake lines through a gap in the fuel tank protector, resulting in excessive corrosion of the brake lines. Note that affected vehicles not currently, or formerly registered, in the salt belt states identified above are eligible for repair, at no cost to the customer, upon request.
Brakes: hoses, lines/piping, and fittings
Risk: Brake line corrosion may result in brake fluid leakage. Fluid leakage may result in longer distances being required to slow or stop the vehicle, increasing the risk of a crash.
Fix: Subaru will notify owners, and dealers will inspect the vehicles. If no brake fluid seepage is observed, the affected area will be rustproofed with anti-corrosion wax. If brake fluid seepage is observed, the brake lines will be replaced followed by rustproofing with anti-corrosion wax. These services will be performed free of charge. The recall began on may 30, 2013. Owners may contact subaru at 1-800-782-2783. Subaru's recall campaign number is wqg-43.
Full defect summary
Subaru is recalling certain model year 2005-2009 outback and legacy vehicles manufactured from december 2003, through april 2009 and currently, or formerly, registered in connecticut, delaware, illinois, indiana, iowa, maine, maryland, massachusetts, michigan, minnesota, missouri, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, west virginia, wisconsin and the district of columbia. Salt water could splash on the brake lines through a gap in the fuel tank protector, resulting in excessive corrosion of the brake lines.
Air bags: side/window
Risk: This may result in failure to provide the intended head protection, increasing the risk of injury to a seat occupant.
Fix: Dealers will replace the left and right side curtain air bag modules. The recall began on june 11, 2004. Owners should contact subaru at 1-800-782-2783. .
Full defect summary
The left and right side curtain air bags in certain vehicles involved in this campaign may not fully deploy rapidly enough when activated in a side impact collision. During a side impact test conducted by the insurance institute for highway safety (iihs), the test results indicated that there was a difference between the iihs test results and the result of side impact tests conducted by fhi.
Recall repairs are free at any franchised dealer. Enter your VIN at nhtsa.gov/recalls to see which recalls are still open on your car.
NHTSA defect investigations
Air bag inflator rupture
Summary
The office of defects investigation (odi) opened pe14-016 in june 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.all six vehicles were operated in florida or puerto rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by takata, a tier-one supplier of automotive air bag systems.during the course of pe14-016, odi determined that five additional vehicle manufacturers used inflators of a similar design and vintage also supplied by takata. No evidence of field failures was found in vehicles produced by these five additional manufacturers.nonetheless, at odi's in
Air bag inflator rupture
Summary
The office of defects investigation (odi) opened pe14-016 in june 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.all six vehicles were operated in florida or puerto rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by takata, a tier-one supplier of automotive air bag systems.during the course of pe14-016, odi determined that five additional vehicle manufacturers used inflators of a similar design and vintage also supplied by takata. No evidence of field failures was found in vehicles produced by these five additional manufacturers.nonetheless, at odi's in
Questions about the 2005 Subaru Outback
- What are the most common problems with the 2005 Subaru Outback?
- By NHTSA owner complaints: suspension (56 complaints, typically around 60,500 miles); speed control (40 complaints, typically around 89,500 miles); air bags (38 complaints, typically around 67,500 miles).
- How many recalls does the 2005 Subaru Outback have?
- 9 recalls listed by NHTSA, the latest from January 2, 2020 (air bags). Check your VIN at nhtsa.gov/recalls to see which ones are still open on your car.
- Is the 2005 a bad year for the Subaru Outback?
- It is 14th of 27 Outback model years by number of complaints, with 273 complaints. Complaint counts are not adjusted for how many cars were sold, so popular years collect more of them, and the newest years have had less time to.