KnownCarProblemsHome › Chevrolet › Silverado 2500 › 2006
2006 Chevrolet Silverado 2500 Problems and Recalls
Owners filed 178 complaints with NHTSA about the 2006 Chevrolet Silverado 2500, most often about the brakes (39% of complaints, typically around 55,500 miles). It is 9th of 27 Silverado 2500 model years by number of complaints.
Most common 2006 Chevrolet Silverado 2500 problems
Brakes
70 complaints · 39%Half of these problems showed up before 55,500 miles. Parts named most often: power assist, antilock/traction control/electronic limited slip.
Tl contact owns a 2006 Chevrolet Silverado 2500 hd. The contact noticed hydraulic fluid leaking from the hydro boost lines. The vehicle was taken to the dealer and they stated that the hydro boost lines failed and caused the leak. The contact was informed that if too much fluid was lost, the braking system would…
I was preparing to slow down as I approached my driveway. When I applied my vehicle's brakes, the brake pedal went completely to the floor. My vehicle did not slow down and I had to utilize me emergency brake and also shift into a lower gear in order to slow down. I was unable to slow down enough to safely make a turn…
Transmission
32 complaints · 18%Half of these problems showed up before 42,000 miles. Parts named most often: automatic transmission, driveline, manual transmission, transfer case (4-wheel drive).
Transmission lines that run from the transmission cooler next to the radiator continue to leak. The lines seem to leak more in colder climates. I am on my third set in 60 days. Transmission fluid was a flammable substance the last I knew.
I had a transmission cooler line to fail and leak badly after 41,000 miles.it was caught in time to prevent transmission failure but how about the next one?it was replaced with a new part at the chevy dealer.
Steering
18 complaints · 10%Half of these problems showed up before 50,000 miles. Parts named most often: hydraulic power assist system, column, linkages, rack and pinion.
Engine idler pulley seized causing serpentine belt to break which resulted in loss of power steering and loss of power brakes..2 local gm dealer parts department's stated this is common on the duramax diesel engine.
The contact owns a 2006 Chevrolet Silverado 2500. The contact stated that noise emitted from the steering column. The contact took the vehicle to the dealer and was informed that the steering gear box and pitman needed to be replaced. The contact also stated that the front bearings and bushings were previously…
Engine
17 complaints · 10%Half of these problems showed up before 40,000 miles. Parts named most often: engine, exhaust system, cooling system.
Exhaust manifold bolts are broken off on both sides of the 6.0 engine, causing exhaust fumes in the passenger compartment when I driving the vehicle. I have owned this vehicle since new and have never had any engine work done to this vehicle.
Tl contact owns a 2006 Chevrolet 2500 hd. While driving downhill between 30-50 MPH, the transmission began shifting out of gear unexpectedly when the brake pedal was depressed. The road surface was icy. The check engine warning indicator illuminated on the instrument panel and remained illuminated until the engine was…
Electrical
14 complaints · 8%Half of these problems showed up before 48,000 miles. Parts named most often: wiring.
Interior heat & A/C blower motor fan suddenly turned on full without warning. Could not turn off. Would not stop even with key removed from ignition.
2006 chev hd2500 blower motor quit working. Tested and found blower motor control module electrical terminal melted along with pigtail connector. We were told by Chevrolet dealership this is a common problem. Replaced control module along with pigtail. Dealership has these parts in stock. May possibly be a fire hazard.
Wheels and tires
13 complaints · 7%Half of these problems showed up before 100,000 miles. Parts named most often: sidewall, valve, tread/belt.
Purchased a set of 4 .federal couragia mt 33/12.50/20 from sd wheelcorp in april 2012. After approx 16000 miles 2 of the four have tread/belt separation creating bubbles on the tires. The tires have always been rotated and correct pressure was maintained. This is a defective and possibly deadly tire and should be…
The contact owns a 2006 Chevrolet Silverado 2500. The vehicle is equipped with federal couragia a/t tires, size 33512.50r/20lt (na). The contact stated that the sidewalls of the tires contained bubbles. The tires were not replaced and the manufacturer was not notified. The VIN was unavailable. The tire failure mileage…
Body and structure
8 complaints · 5%Half of these problems showed up before 50,000 miles. Parts named most often: frame and members, body.
Tl contact owns a 2006 Chevrolet Silverado 2500. The contact placed a snow plow on the vehicle. While driving 10 MPH, the front differentials and axles failed. The contact called the gm manufacturer and they stated that he should have not placed a snow plow on a diesel vehicle. The contact feels that the vehicle is…
The contact owns a 2006 Chevrolet Silverado 2500. The contact stated that there was corrosion on the frame of the vehicle. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 64,000.
Air bags
8 complaints · 5%Half of these problems showed up before 101,000 miles.
The contact owns a 2006 Chevrolet Silverado 2500. The contact stated that the front impact sensor failed and the air bag warning light was illuminated. The manufacturer was notified of the failure and was unable to provide a replacement part because the part was no longer manufactured. The manufacturer was notified of…
7-12-14, 11:15 mtn time my wife and I were driving westbound on I-76, in a 2006 chevy silverado, 2500 hd duramax diesel towing a 24" catalina 5th wheel, approximately 6,500 lbs, in the right hand lane, at approximately 50 MPH in commerce city, co approaching 104th ave. At the 104th ave overpass a drunk driver pulled…
Complaints are owner reports to NHTSA, not verified defects. One complaint can name several components, so shares add up to more than 100%.
2006 Chevrolet Silverado 2500 recalls
NHTSA lists no recalls for this model year.
Recall repairs are free at any franchised dealer. Enter your VIN at nhtsa.gov/recalls to see which recalls are still open on your car.
Questions about the 2006 Chevrolet Silverado 2500
- What are the most common problems with the 2006 Chevrolet Silverado 2500?
- By NHTSA owner complaints: brakes (70 complaints, typically around 55,500 miles); transmission (32 complaints, typically around 42,000 miles); steering (18 complaints, typically around 50,000 miles).
- How many recalls does the 2006 Chevrolet Silverado 2500 have?
- NHTSA lists no recalls for the 2006 Chevrolet Silverado 2500. Check your VIN at nhtsa.gov/recalls in case one is issued later.
- Is the 2006 a bad year for the Chevrolet Silverado 2500?
- It is 9th of 27 Silverado 2500 model years by number of complaints, with 178 complaints. Complaint counts are not adjusted for how many cars were sold, so popular years collect more of them, and the newest years have had less time to.